Argo Ulisse 10 AUR101CL Manual de servicio

TECHNICAL DATA & SERVICE MANUALROOM AIR CONDITIONER WITH REMOTE CONDENSER- AUR101CL- AUR131CL- AUR101HLCOOLING ONLY VERSION (R407C)HEAT PUMP VERSI

10FFUNCTION1 Cool Mode Operation(RT - SPT) [oc]+3+2+10-1ONOFFONOFFHLMONOFFCOMPOFANIFANRVover 3 min over 5 minover 30 secIn Cool Mode, the operation of

2 Heat Mode Operation(RT - SPT) [oc]+10-1-2-3HOFFLMONOFFNote 1 Note 2COMPIFANRVONOFF30 secThe Heat Mode operation is similar to the Cool Mode operatio

3 Auto (Cool/Heat) Mode Operation(RT - SPT) [oc]+2+10-1-2ONOFFONOFFCOMP& OFANRVAuto Heat Mode Auto Cool Mode Auto Heat ModeIn Auto Mode, the unit

4 Dry Mode OperationDRY(RT - SPT) [oc]+2+10-1-2ONOFFLOWOFFDRY-ONDRY-OFFTime [min]10203040 50COMP& OFANIFAN5 minutes COMPON timeMax 15 minutes Max

6 Protection Operations in Cool and Dry Modes1. Indoor Coil Defrost ProtectionThe in-coil defrost protection can prevent the ice formation at the in-

2. Outdoor Coil High Pressure ProtectionThe out-coil high pressure protection prevent the build up of high pressure at the out-coil during coolingoper

7 Protection Operations in Heat Mode 7-1 Outdoor Coil Deice ProtectionThe deice process is controlled by an Ice Detection Algorithm (IDA). The IDA

Explanation:The “Ice Forming Detection” will be done by two algorithms –1. In Dynamic Temp Detection, the ice formation will be detected by(i) Compare

7-2 Indoor Coil High Pressure Protection in Heat ModeThe in-coil high pressure protection prevent the build up of high pressure at the in-coil during

8 Cold Draft Prevention (Heating) • This function controls indoor fan speed so a strong draft of cold air will not blow out before the indoor heat e

PageA SPECIFICATIONS31) Unit specifications 32) Major Component specifications 4B OPERATING RANGE5C DIMENSIONAL DATA6D PERFORMANCE CHARTS7E REFRIGERAN

9 Sleep FunctionRoom temperature is automatically controlled to compensate for body temperature variations whilesleeping. This mode of operation is d

12 Manual Unit Control and LED indicatorsThe push button switch and the LED indicators on the display panel let the user to control the unitoperation

22ELECTRIC WIRING - COOLING ONLY VERSION • SCHEMA ELETTRICO - VERSIONE SOLO RAFFREDDAMENTO• SCHÉMA ÉLECTRIQUE -VERSION FROID SEUL• SCHALTPLAN - AUSFÜ

23ELECTRIC WIRING - HEAT PUMP VERSION • SCHEMA ELETTRICO - VERSIONE POMPA DI CALORE• SCHÉMA ÉLECTRIQUE - VERSIONPOMPE À CHALEUR• SCHALTPLAN - WÄRMEP

24HTROUBLESHOOTINGASYSTEMATIC CHART OF «TROUBLESHOOTING»Circuit breaker trips (or fuse blows)AIR CONDITIONER DOES NOT OPERATECHECK BEFORE AND AFTER «T

25Water - level alarm (condensate) is blinkingMalfunctioning of the condensate drainage system to the outdoor unitNOTE - In case of emergency the air

26SOME PART OF AIR CONDITIONER DOES NOT OPERATE1) ONLY INDOOR FAN DOES NOT RUN2) ONLY OUTDOOR FAN DOES NOT RUN3) ONLY COMPRESSOR MOTOR DOES NOT RUNDEF

27NOYESNOTry to run using another remote controlunit.Check for residue duildup on transmitterof remote control unit.Check for residue buildup on remot

(5) Check setting temperature.If fuse blows, there is apossibility of short circuit.Check fuse on PCB Ass’y in indoor unitfor continuity.Measure resis

YESNOPOOR COOLING OR POOR HEATINGCheck position of remote controlunit.Cool or warm air from air conditionerreaches position directly.Are wide and narr

3Controls / temperature control Microprocessor / I.C. ThermostatControl unit Wireless remote control unitTimer ON / OFF 24 hours and programFan speed

ICT (indoor coil sensor) OCT (outdoor coil sensor) RAT (room ambient temperature) are defective. NOTE Allarm signal (*) Stanby lamp o

31STANDARD UNIT 910 g 1220 g 1030 gUNIT WITH EXTENSION KIT OF 2 m 960 g 1270 g 1090 gUNIT WITH EXTENSION KIT OF 4 m 1010 g

32Before starting the bleeding of the system, it is advisable to oil the quick connections with antifreezing oil(HAB OIL), and then connect and discon

33LCHECKING ELECTRICAL COMPONENTS1) Measurement of Insulation Resistance●The insulation is in good condition if the resi-stance exceeds 1MOhm.NOTEPow

343) Checking Motor Capacitor●Remove the lead wires from the capacitor termi-nals, and then place a probe on the capacitor ter-minals as shown in Fig

Printed in italyVia Varese, 90 - 21013 Gallarate - Va - ItalyTel. +39 0331 755111 - Fax +39 0331 776240www.argoclima.it

2) MAJOR COMPONENT SPECIFICATIONSa) INDOOR UNITMODELAUR101CLAUR131CLAUR101HLCONTROLLER P.C.B.Controls MicroprocessorControl circuit fuse 250 VAC - 3.1

b) OUTDOOR UNIT (LITTLE BAG)MODELAUR101CLAUR131CLAUR101HLFAN & FAN MOTORPropeller Propeller PropellerNumber / Diameter mm 1 / ø 320 1 / ø 380 1 /

6CDIMENSIONAL DATAIndoor unitOutdoor unit580835245230440425DIMENSIONS: mm * HEAT PUMP MODEL AND AUR131CL790580440 (* 490) 230 (* 250)435 (* 490)245

75.25.04.84.64.44.24.03.83.63.43.2DPERFORMANCE CHARTS20OPERATING CURRENT - A253230 35 40 4527197.06.56.05.55.04.54.03.53.0OPERATING CURRENT - AOUTDOOR

8…3227195.55.04.54.03.53.0-10 -5 0 5 10 15 20 25……242018………5.25.04.84.64.44.24.03.83.63.43.23.0OPERATING CURRENT - AOUTDOOR INLET AIR D.B. TEMP. (°C)I

9E REFRIGERANT FLOW DIAGRAM COOLING MODELSQUICKCONNECTORCAPILLARYTUBECompressor AccumulatorMechanical filterHeat exchangerHeat exchangerOutdoor unit